Volvo S60 1 generation was produced in 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009 with the body designation RS, RH. During this time, the model was restyled. In our article, you will find information about the location of electronic control units, a description of the fuses and relays of the Volvo S60 with block diagrams, photo examples of their execution and location. We will highlight the fuse responsible for the cigarette lighter.
The purpose of fuses and relays may differ from that shown and depends on the year of manufacture, region of delivery and the level of electrical equipment of your car.
Location
General layout of electronic control units
| 1 | Electronic air conditioning control unit |
| 2 | Air Conditioner/Heater Fan Control Unit – Next to Fan Motor |
| 3 | Vehicle tilt sensor (anti-theft system) |
| 4 | Anti-theft alarm sound signal – behind the front right wheel arch trim |
| 5 | Volume change sensor (anti-theft system) – ceiling panel |
| 6 | Anti-theft alarm sensor – in the multifunctional control unit З |
| 7 | Electronic control unit of the audio system |
| 8 | Additional heater control unit, if installed |
| 9 | Battery pack – under the hollow luggage compartments |
| 10 | Cruise control unit integrated into the engine control unit. |
| 11 | Diagnostic Link Connector (DLC) |
| 12 | Differential lock control unit – on the rear differential (4×4) |
| 13 | Driver’s door electrical equipment control unit – in the door – functions: Central locking, indicators of open or not tightly closed door, electric drive/heater of rear-view mirrors on doors, electric drive of windows, lighting lamps in door mirrors |
| 14 | Passenger door electrical equipment control unit – in the door – functions: Central locking, open or not tightly closed door indicators, electric drive/heater for rear view mirrors on the doors, electric drive for windows, lighting lamps in door mirrors |
| 15 | Cooling system fan motor control unit |
| 16 | Fuse/Relay Box, Engine Compartment 1 |
| 17 | Fuse/Relay Box 2 in Engine Compartment – Under Fuse/Relay Box 1 in Engine Compartment |
| 18 | Fuse/Relay Box, Instrument Panel 1 |
| 19 | Fuse/Relay Box, Instrument Panel 2 |
| 20 | Fuse/Relay Box, Luggage Compartment 1 |
| 21 | Fuse/relay box in luggage compartment 2 – next to the battery |
| 22 | Headlight control unit, left (models with xenon headlights) |
| 23 | Headlight control unit, right (models with xenon headlights) |
| 24 | Sound signals |
| 25 | Immobilizer – in the electronic engine control unit |
| 26 | Ring antenna of the immobilizer – near the ignition switch |
| 27 | Instrument cluster control unit – instrument panel |
| 28 | Lighting control unit – behind the headlight switch |
| 29 | Multifunctional control unit is connected to the fuse/relay block 2 of the instrument panel – functions: Anti-theft alarm system, central locking, electric windows, windshield wiper/washer, headlight wiper/washer, power steering, immobilizer, headlights, direction indicators/hazard warning lights, horn, front/rear side lights, starter, heated seats. Headlight range control, fuel pump, glove compartment light, central brake light. |
| 30 | Multifunction control unit 2 – connected to fuse/relay box, luggage compartment 1 – functions: Anti-theft alarm system, central locking, rear lights, fuel gauge, interior lights, rear window heater, auxiliary power socket – rear, under fuel filter heater – Diesel, rear seat headrests. |
| 31 | Multifunctional control unit 3 – in the interior rearview mirror – functions: Central locking, anti-theft system, sunroof, rain sensor, interior lights, seat belt reminder |
| 32 | Navigation system control unit |
| 33 | Ambient air temperature sensor – in the right door mirror |
| 34 | Rain sensor (if installed) |
| 35 | Relay for door locking system against accidental opening, left – in the door |
| 36 | Relay for door locking system against accidental opening, right – in the door |
| 37 | Electric Seat Control Unit – Under Seat, Driver’s Side |
| 38 | Side Impact Sensor, Left Front – B-Pillar |
| 39 | Side impact sensor, right front – B-pillar |
| 40 | Side impact sensor, rear left – behind the support on the rear seat cushion |
| 41 | Side impact sensor, rear right – behind the support on the rear seat cushion |
| 42 | SRS Electronic Control Unit |
| 43 | Steering Wheel Position Sensor Unit – Connected to Fuse/Relay Box 2 under the dash |
| 44 | Steering wheel electrical control unit – behind the steering wheel – functions: Audio system, cruise control, horn, turn signals, windshield wiper/washer, low/high beam headlights, trip computer |
| 45 | Electric sunroof drive control unit |
| 46 | Suspension control unit – on the side of the center console |
| 47 | Electronic control unit of the gearbox |
| 48 | Gear shift control unit |
| 49 | Telematics unit |
Blocks in the cabin
Fuse box 1
At the left end of the instrument panel, behind the protective cover, is the first block of fuses.
Check the purpose of the elements with your diagrams on the block cover.
| 1 | 10A 2001-2002: Low beam headlights, left |
| 15A 2003-2004: Low beam, Bi-Xenon | |
| 25A 2005-2009: Driver’s seat with electric adjustment | |
| 2 | 10A 2001-2002: Low beam headlights, right |
| 20A 2003-2004: High beam | |
| 25A 2005-2009: Power Passenger Seat | |
| 3 | 15A 2001-2002: Low beam |
| 30A 2003-2004: Power Driver Seat | |
| 30A 2005-2009: Air Conditioning Fan | |
| 4 | 20A 2001-2002: High beam |
| 30A 2003-2004: Power Passenger Seat | |
| 25A 2005-2009: Control unit right, front door | |
| 5 | 30A 2001-2002: Driver’s Power Seat |
| 15A 2003-2004: Power Steering, Vacuum Pump | |
| 25A 2005-2009: Control unit left, front door | |
| 6 | 30A 2001-2002: Power Passenger Seat |
| 5A 2004; Bi-Fuel: Gas cylinder valve | |
| 10A 2005-2009: General lighting, ceiling (RCM), upper electronic control module (UEM) | |
| 7 | 15A 2001-2004: Seat Heater (Front Left) |
| 15A 2005-2009: Sunroof | |
| 8 | 15A 2001-2004: Seat Heater (Front Right) |
| 7.5A 2005-2009: Ignition switch, SRS system, Engine control module (ECM), Passenger side SRS off (PACOS), Electronic start immobilizer (IMMO), Transmission control module (TCM; diesel and R-models – for 2006) | |
| 9 | 5A 2001-2004: ABS / STC (2003-2004) / DSTC (2003-2004) |
| 5A 2005-2009: OBDII, Light Switch (LSM), Steering Angle Sensor (SAS), Steering Wheel Module (SWM) | |
| 10 | 15A 2001-2002: High beam, left |
| 20A 2005-2009: Audio | |
| 11 | 15A 2001-2002: High beam, right |
| 30A 2005-2009: Audio Amplifier | |
| 12 | 15A 2001-2004: Headlight range control (2004), headlight washers |
| 10A 2005-2009: RTI display | |
| 13 | 20A 2001-2002: 12V socket |
| 15A 2003-2004: 12V socket | |
| 5A 2005-2009: Phone | |
| 2005-2009: 14-38 – Not used | |
| 14 | 5A Power Passenger Seat, Front Seat Belts (2001-2002) |
| 15 | 5A 2001-2003: Audio, VNS |
| 5A 2004: RTI Audio | |
| 16 | 20A Audio |
| 17 | 30A Amplifier |
| 18 | 5A 2001-2002: Front Fog Lights |
| 15A 2003-2004: Front Fog Lights | |
| 19 | 10A 2001-2003: VNS |
| 10A 2004: RTI display | |
| 20 | 5A 2002: Transport Switch |
| 21 | 20A Automatic transmission, gear selector lock, D2 |
| 22 | 20A Direction indicators |
| 23 | 5A Light switch, diagnostic socket, steering wheel module, climate control unit / convenience unit |
| 24 | 10A 2001-2002: Climate control unit, driver’s seat with electric adjustment, instrument cluster |
| 10A 2003-2004: Climate control unit, driver’s seat with electric adjustment, instrument cluster, parking heater | |
| 25 | 10A 2001-2002: Ignition Switch, Central Electronic Module, Starter Relay |
| 10A 2003: Ignition Switch, SRS, Starter Relay, Engine Control Module | |
| 10A 2004: Ignition Switch, Central Electronic Module, Starter Relay, Engine Control Module | |
| 26 | 30A Air conditioning control unit |
| 27 | 15A 2001-2002: Front Door Electronic Module |
| 15A 2004: FOUR-C Active Chassis | |
| 28 | 10A Ceiling module, interior lighting |
| 29 | 10A Telephone |
| 30 | 10A 2001-2002: Parking Lights (Left) |
| 7.5A 2003-2004: Parking lights (left) | |
| 31 | 10A 2001-2002: Parking lights (right), license plate light |
| 7.5A 2003-2004: Side lights (right), license plate light | |
| 32 | 10A Central Electronic Module, Sun Visor Mirror Light, Power Steering, Glove Box Light (2003-2004), Interior Light (2003) |
| 33 | 15A Fuel Pump |
| 34 | 15A Hatch |
| 35 | 25A Central locking, electric windows, left mirror with electric drive |
| 36 | 25A Central locking, electric windows, right mirror with electric drive |
| 37 | 30A Rear power windows, child safety lock (2003-2004) |
| 38 | 5A 2003-2004: Anti-theft alarm siren |
Fuse box 2
Another fuse box is installed under the instrument panel, next to the diagnostic connector, mainly in models produced between 2004 and 2009.
Photo – example
To access it, you need to unscrew the protection fastener.
| 1 | 15A Seat heating, right side |
| 2 | 15A Seat heating, left side |
| 3 | 15A Sound signal |
| 4 | Backup socket |
| 5 | 10A Infotainment system |
| 6 | Backup socket |
| 7 | Backup socket |
| 8 | 5A Security Alarm Siren |
| 9 | 5A Brake light contacts, power supply |
| 10 | 10A Combined instrument panel (DIM), air conditioning system (CCM), parking heater, electric driver’s seat |
| 11 | 15A 12V socket (cigarette lighter) , front seat, rear seat and refrigerator |
| 12 | Backup socket |
| 13 | Backup socket |
| 14 | 15A S60 R, 2005-2006: Headlight Washers |
| 15 | 5A ABS, STC/DSTC |
| 16 | 10A Electronic Power Steering (ECPS), Active Bi-Xenon (ABS), Headlight Beam Height Adjustment |
| 17 | 7.5A Fog light, front left |
| 18 | 7.5A Fog light, front right |
| 19 | Backup socket |
| 20 | 5A Coolant pump (V8) |
| 21 | 10A Communication Control Module (TOM), Reverse Gear Lock (M66) |
| 22 | 10A High beam headlights, left |
| 23 | 10A High beam headlights, right |
| 24 | Backup socket |
| 25 | Backup socket |
| 26 | Backup socket |
| 27 | Backup socket |
| 28 | 5A Power Passenger Seat |
| 29 | 7.5A Fuel Pump |
| 30 | 5A BUS |
| 31 | Backup socket |
| 32 | Backup socket |
| 33 | 20A Vacuum Pump |
| 34 | 15A Headlamp Washer Fluid Pump |
| 35 | Backup socket |
| 36 | Backup socket |
Fuse number 11 is responsible for the operation of the cigarette lighter.
Relay block
This unit is installed under the dashboard in early Volvo s60 models. Also known as the central electronic module CEM. It looks something like this:
| 1 | — |
| 2 | Auxiliary ignition circuits |
| 3 | Main ignition circuits |
| 4 | — |
| 5 | — |
| 6 | Electric window lifter – closing, left rear door |
| 7 | Electric window lifter – opening, left rear door |
| 8 | disabling rear window lifter motors, locking doors from accidental opening – rear doors |
| 9 | high beam headlights |
| 10 | Clearance lamps |
| 11 | Daytime lighting system |
| 12 | low beam headlights |
| 13 | Electric window relay – close, right rear door |
| 14 | Electric window relay – open, right rear door |
| 15 | Relay 2 auxiliary ignition circuits |
| 16 | Transmission control system |
| 17 | — |
| 18 | — |
| 19 | — |
| 20 | — |
| 21 | Telematics |
| 22 | — |
| 23 | — |
| 24 | — |
| 25 | — |
| 26 | — |
| 27 | Fog lights |
| 28 | Fuel pump relay |
| 29 | — |
| 30 | Fuel leakage control system relay |
| 31 | Jumper – left turn signals |
| 32 | Jumper – Right direction indicators |
| 33 | — |
| 34 | Jumper – low beam headlights |
| 35 | — |
Block under the hood
On the left side of the engine compartment, next to the pillar, there is a block with fuses and relays. There are several possible versions of this block with fuses and relays.
Option 1
- 60A – Glow Plug Control Unit, Glow Plugs, Glow Plug
- 60A – Electric motor, electric cooling fan
- –
- –
- –
Fuse diagram
| 1 | 30A ABS |
| 2 | 30A ABS |
| 3 | 35A High Pressure Headlamp Washers |
| 4 | 25A Parking heater (optional) |
| 5 | 20A Additional lights (optional) |
| 6 | 35A Starter Relay |
| 7 | 25A Windscreen Wipers |
| 8 | 15A Fuel Pump Fuse |
| 9 | 15A Transmission Control Module (TCM), (V8, diesel, 6-cyl. gasoline) |
| 10 | 20A Ignition coils (petrol), engine control module (ECM), injector valves, (diesel) |
| 11 | 10A Fuel Pedal Position Sensor (APP), AC Compressor, Fan, Electronic Unit |
| 12 | 5/15A Engine Control Module (ECM) (petrol), injectors (petrol), air flow meter (petrol); air flow meter (diesel) |
| 13 | 10/15A Throttle Control Module (V8), V1S (6-cyl. gasoline); Throttle Control Module, Solenoid Valve, SWIRL (Air-Mixture Valve), Fuel Pressure Regulator (Diesel) |
| 14 | 10/20A Lambda probe (petrol); lambda probe (diesel) |
| 15 | 10/15A Crankcase ventilation heater, solenoid valves, leak diagnostics (5-cyl. petrol); Crankcase ventilation heater (V8, 6-cyl. petrol), AC clutch (V8, 6-cyl. petrol), solenoid valves, leak diagnostics (V8, 6-cyl. petrol), ECM, (V8, 6-cyl. petrol), air flow meter (V8), glow plugs (diesel) |
| 16 | 20A Low beam headlights, left |
| 17 | 20A Low beam headlights, right |
| 18 | Backup socket |
| 19 | 5A Engine Control Module (ECM), Power, Engine Relay |
| 20 | 15A Side lights |
| 21 | 20A 2009 : Vacuum pump |
Relay diagram
- FMA1 – Starter
- FMA2 – Glow Plug Automatic Relay, Not I5D
- FMA3 – Engine Management System Main Relay
- FMI2 – Relay, climate control
- FST1 – Windshield Wiper Relay, Low/High Speed
- FST2 – Windscreen wiper interval relay
- FST3 – Relay, High Pressure Headlamp Washer Motor
Option 2
Photo – example
| F1 | 25A Additional heater control unit |
| F2 | 20A Additional equipment / Additional lights |
| F3 | 10A 2005: Throttle Body (5-cyl. non-turbo/bi-fuel) |
| F4 | 20A Petrol: Lambda Sensor 2004-2005 ; Diesel: Engine Control Module (ECM), High Pressure Fuel Valve |
| F5 | 10/ 15A Engine Management System (Air Flow Meter, Engine Control Unit, Injectors, Crankcase Ventilation Heater, Solenoid Valves) |
| F6 | |
| F7 | 10A 2001-2004: Throttle Control Unit |
| F8 | 10A Fuel Pedal Position (APP) Sensor, AC Compressor, ECU Fan (2003-2005) |
| F9 | 15A Horn 10A 2005; Bi-fuel LPG: Gas cylinder valve |
| F10 | – |
| F11 | 20A 2001-2004: A/C Compressor, Ignition Coils, Fan (2001-2002), Solenoid Valves (2004; Diesel) 2005: Ignition Coils, Relay Coils |
| F12 | 5A Brake lights |
| F13 | 25A Windscreen Wiper |
| F14 | 30A Anti-lock brake system ABS/ESP (DST C) |
| F15 | 15A 2004; Bi-Fuel: Gas cylinder valve / 35A 2005: High pressure headlamp washers |
| F16 | 15A Windscreen wipers, headlight washers |
| F17 | 10/20A Right headlight – low beam (xenon) |
| F18 | 10/20A Left headlight – low beam (xenon), 15A 2005 Front side lights |
| F19 | 30A Anti-lock braking system ABS/ESP (DSTC) |
| F20 | 15/20A Left headlight – high beam |
| F21 | 15/20A Right Headlight – High Beam 2005 2005: Fuel Pump |
| F22 | 25/35A Starter |
| F23 | 5A Engine Management System Relay, Engine Control Module (ECM) |
| F24 | — |
Relay diagram
Engine management system- Glow plugs
- Starter
- Intermittent windshield wiper operation
- Headlight cleaner/washer
- Air conditioning compressor electromagnetic clutch
- Beep (signal)
- Windshield washer pump
- Windshield wiper motor
- Rear window washer pump motor
Additional protective elements are installed on the back side of the block.
| F1 | 60A Glow Plugs |
| F2 | 60A Passenger Compartment End Block Circuits: Fuses (F5-7), (F25-27), (F32-33) |
| F3 | 60A Passenger Compartment End Block Circuits: Fuses (F3-4), (F8-11), (F16-19), (F34-38) |
| F4 | 60A Passenger compartment end block circuits: fuses (F1), (F12-15), (F20-24) |
| F5 | Empty |
| F6 | Empty |
| F7 | Empty |
| F8 | 60A Cooling Fan Motor |
Blocks in the trunk
In the luggage compartment, on the left behind the passenger compartment protection, another block with fuses and relays is installed. To access it, you need to turn the holder.
Option 1
The block itself will look something like this.
| F1 | 10A Multifunction control unit 2, interior lighting – luggage compartment lighting |
| F2 | 10A Rear fog lights |
| F3 | 15A Brake lights |
| F4 | 10A Reversing lights |
| F5 | 5A Rear Window Defogger, Trailer Electrical Equipment Socket Power Relay |
| F6 | 10A Rear door opening drive |
| F7 | 10A Folding headrests |
| F8 | 15A Central locking – rear side door lock/rear door fuel filler flap/cap |
| F9 | 20A Trailer Electrical Socket |
| F10 | 5A Antenna Signal Booster, LED |
| F11 | 15A Additional equipment |
| F12 | – |
| F13 | – |
| F14 | 7.5A Brake lights |
| F15 | 20A Trailer Electrical Socket |
| F16 | 15A Socket in the Luggage Compartment |
| F17 | 7.5A Fuel filter heater (Diesel), differential lock control unit |
| F18 | 15A Fuel filter heater (diesel) |
| 1 | — |
| 2 | — |
| 3 | — |
| 4 | Rear Window Wiper Intermittent Relay |
| 5 | Relay of two-component fuel supply system Bi-fuel |
| 6 | A/C Electronic Control Unit Relay – Rear A/C |
| 7 | Rear Door Actuator Relay |
| 8 | Not used(2002) |
| 9 | Fuel filler neck lock actuator relay – opening |
| 10 | — |
| 11 | Right rear door central locking relay – unlocking |
| 12 | — |
| 13 | — |
| 14 | Rear Window Wiper Motor Relay |
| 15 | — |
| 16 | — |
| 17 | — |
| 18 | — |
| 19 | Jumper – brake lights |
| 20 | Jumper – rear dimensions |
| 21 | Jumper – rear dimensions |
| 22 | Jumper connector for power supply of additional equipment in the luggage compartment |
| 23 | Jumper – Fog lights |
| 24 | — |
| 25 | Rear Fog Light Relay – Trailer |
| 26 | Rear Fog Light Relay |
| 27 | Brake light relay |
| 28 | Reverse Light Relay |
| 29 | Central lock relay, rear – double lock |
| 30 | Left Rear Door Central Locking Relay – Unlocking |
| 31 | Fuel filler neck lock actuator relay – closing, central locking relay – rear doors – closing (2002) |
| 32 | Fuel filter heater relay (diesel) |
| 33 | — |
| 34 | Rear Window Defogger Relay |
| 35 | Audio system |
| 36 | Trailer Electrical Equipment Socket Power Relay |
Option 2
Photo – example
| 1 | 10A Reversing light |
| 2 | 20A Side lights, fog lights, luggage compartment light, number plate light, brake lights |
| 3 | 15A Accessories (AEM) |
| 4 | Backup socket |
| 5 | 10A Electronic Equipment REM |
| 6 | 7.5A Rear Seat Entertainment System RSE (Accessory) |
| 7 | 15A Wiring (30 Power) |
| 8 | 15A Electrical Socket in Luggage Compartment |
| 9 | 20A Rear door, right: window lift, window lift lock |
| 10 | 20A Rear door, left: window lift, window lift lock |
| 11 | Backup socket |
| 12 | Backup socket |
| 13 | 15A Diesel Filter Heater |
| 14 | 15A Subwoofer, Rear Air Conditioning (A/C) |
| 15 | Backup socket |
| 16 | Backup socket |
| 17 | 5A Additional audio equipment |
| 18 | Backup socket |
| 19 | 15A Folding headrest |
| 20 | 20A Wiring (15 Power) |
| 21 | Backup socket |
| 22 | Backup socket |
| 23 | 7.5A AWD |
| 24 | Backup socket |
| 25 | Backup socket |
| 26 | 5A Parking Assistance |
| 27 | 30A Main Fuse: Trailer Harness, Park Assist, AWD |
| 28 | 15A Central Locking (PCL) |
| 29 | 25A Trailer lighting left: side lights, direction indicators |
| 30 | 25A Trailer lighting, right: brake light, rear fog light, direction indicators |
| 31 | 40A Main fuse |
| 32 | Backup socket |
| 33 | Backup socket |
| 34 | Backup socket |
| 35 | Backup socket |
| 36 | Backup socket |
| 37 | 20A Electrically heated rear window |
| 38 | 20A Electrically heated rear window |